Rinnai ENERGYSAVER ES38 Installationshandbuch

— Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. — WHAT TO DO IF YOU SMELL GAS •

10Rinnai Corporation ES38 ManualCare and Maintenance FiltersDirty filters reduce the air flow and the appliance’s ability to produce heat. The fil

11Rinnai Corporation ES38 ManualBefore Making a Service Call Before making a service call please check the following: At Ignition:Heater does not oper

12Rinnai Corporation ES38 ManualFault Codes If there is a malfunction the appliance may shut down as a safety precaution and display a fault

13Rinnai Corporation ES38 ManualTroubleshooting ProblemRemedyCauseNot Plugged InPower Failure(Initial Installation)Air In Gas PipeGas Filter Bloc

14Rinnai Corporation ES38 ManualInstallation Instructions • A qualified service technician should install the appliance and inspect it before use. •

15Rinnai Corporation ES38 ManualGas Connection • The gas supply line shall be gas tight, sized and so installed as to provide a supply of a gas

16Rinnai Corporation ES38 ManualFlue Terminal Clearances XVAIR SUPPLY INLET VENT TERMINAL AREA WHERE TERMINAL IS NOT PERMITTTED INSIDECORNER DE

17Rinnai Corporation ES38 ManualFlue Terminal Clearances Ref Description Canadian Installations US Installations AClearance above grade, veranda, p

18Rinnai Corporation ES38 ManualDimensions inches (mm) 14 1/16" (357.5)12 7/16" (316)13" (330)7 7/8" (200)4

Installation Parts The following items are included with the appliance: “A” Vent Kit, FOT-151 Flue Manifold ...1Spare rubber

2Rinnai Corporation ES38 ManualThis appliance may be installed in an aftermarket, permanently located, manufactured home (USA only) or mobile home, wh

20Rinnai Corporation ES38 ManualDrilling Flue Hole Ensure that there are no gas or water lines, or electrical circuits in the wall l

21Rinnai Corporation ES38 ManualFlue Manifold Installation 1. Disassemble the flue manifold The flue consists of 3 parts: • sleeve • inside con

22Rinnai Corporation ES38 ManualFlue Manifold Installation 5. Lock the ties Pulling hard on the left and right hand ties, clip the ties over the

23Rinnai Corporation ES38 ManualExtension Kit Installation Vent extensions installed in unconditioned air space must be insulated with high temperat

24Rinnai Corporation ES38 ManualClearancesexhaust pipe to combustibles 1 inch (25.4 mm) exhaust pipe to non-combustibles zero Extension Kit Installa

25Rinnai Corporation ES38 ManualExtension Kit Installation Extension Kits and Parts A FOT-102(11.4-20.3 inch)B FOT-103(21.0-39.6 inch)A FOT-102(29.5

26Rinnai Corporation ES38 ManualConnecting the Appliance 1. Attach flue adapter to the flue manifold with pipe stopper S. 2. Attach the air inle

27Rinnai Corporation ES38 ManualOperating Instructions FOR YOUR SAFETY READ BEFORE OPERATING WARNINGoitcurtsni eseht wollof ton od uoy fI ns exactly,

28Rinnai Corporation ES38 ManualCut-Away Diagram

29Rinnai Corporation ES38 ManualWiring Diagram If any of the original wire as supplied with the appliance must be replaced, it must be replaced

3Rinnai Corporation ES38 ManualWARNINGCAUTION Safety Behavior and Practices • Do not block the warm air discharge. Do not

30Rinnai Corporation ES38 ManualLadder Diagram

31Rinnai Corporation ES38 ManualParts List For replacement parts call Rinnai at 1-800-621-9419.

32Rinnai Corporation ES38 ManualParts List

33Rinnai Corporation ES38 ManualParts List

34Rinnai Corporation ES38 ManualParts List 144148147146145926924149145146924925150152904137139140141901111110107109901142909141140139143712431

35Rinnai Corporation ES38 ManualParts List

36Rinnai Corporation ES38 ManualParts List

37Rinnai Corporation ES38 ManualParts List

38Rinnai Corporation ES38 ManualParts List No DRAWING No. PART NAMEQTYREMARKS1004RFA1004RFA-W001 1001F-073-9 SIDE PANEL I 21001F-073-4 SIDE PA

Parts List 39Rinnai Corporation ES38 ManualNo DRAWING No. PART NAMEQTYREMARKS1004RFA1004RFA-W111 1001F-175 ELECTRODE SEAL PACKING 1 1112 RHF25

4Rinnai Corporation ES38 Manual )ylno ASU( emoh derutcafunam roF noitacilppA or mobile home or residential installation convertible for use with natur

40Rinnai Corporation ES38 ManualParts List No DRAWING No. PART NAMEQTYREMARKS1004RFA1004RFA-W171 1001F-053 SEAL PACKING 1 1172 1001F-153-2 COM

Parts List 41Rinnai Corporation ES38 ManualNo DRAWING No. PART NAMEQTYREMARKS1004RFA1004RFA-W800CP-74167-27 RATING PLATE1 1800CP-74167-28 RATI

42Rinnai Corporation ES38 ManualConsumer Support Warranty Information Limited Warranty Gas Direct Vent Wall Furnace What is covered? This W

43Rinnai Corporation ES38 ManualLimited Warranty - continued Replacement of the product may be authorized by Rinnai only. Rinnai does not authorize a

Rinnai America Corporation 103 International Drive Peachtree City, GA 30269 TOLL FREE: 1-800-621-9419 www.rinnai.us © 2009 Rinnai America Corporation

5Rinnai Corporation ES38 ManualFeatures• Restarts automatically when ignition or combustion fails. • Clean Heating Forced Flue Type • Easy Operati

6Rinnai Corporation ES38 ManualGetting to know your new heating appliance Operating Instructions CONTROL PANELOPERATION/TEMPERATURE

7Rinnai Corporation ES38 ManualControl Panel All buttons beep when operated. Set TempRoom TempEconomyTempControlFunction LockFilterON/OFFONFUNCTIO

8Rinnai Corporation ES38 ManualOperating the Heater Turning the heater ON When you press and release the ON/OFF button, the Temperature Level lamps w

9Rinnai Corporation ES38 ManualCAUTIONAdjusting Air Flow Direction The vertical louvers may be adjusted to move the air flow more to the right or to t